PEGESORB rapid suture is sterile synthetic, absorbable, braided and coated surgical multifilament sutures. The sutures are made of polyglycolic acid and the empirical formula of the polyglycolic acid is (-O-CH2-CO-O-CH2-CO-)n. The braid structure of the suture is coated. Coated suture is prepared by poly(glycolide(%30)-co-L-lactide(%70) and calcium stearate mixture.
Polyglycolic acid sutures when introduced into a living organism are absorbed by that organism and cause no undue tissue irritation. Polymer and the coating with calcium stearate have been shown to be non-antigenic, non-pyrogenic, and elicit only a mild tissue reaction during absorption. PEGESORB rapid has excellent handling and knotting properties with minimum tissue response.
The sutures are undyed (natural, beige).
PEGESORB rapid is the lower molecular weight form of PEGESORB, which enables rapid hydrolysis/absorption of PGA.
PEGESORB rapid meet all requirements for synthetic absorbable surgical sutures specified at the European Pharmacopoeia (EP) and United States Pharmacopoeia (USP).
PEGESORB rapid is indicated only for use in soft tissue approximation where only short term wound support (7-10 days) is required including ophthalmic surgery. PEGESORB rapid is not indicated for use in cardiovascular and neurological tissues.
Sutures are for single use only.
PEGESORB rapid elicits a minimal tissue reaction and ingrowth of fibrous connective tissue. Progressive loss of tensile strength and eventual absorption of PEGESORB rapid suture occurs by means of hydrolysis gradually and decreases the strength in the body.
The absorption process begins a loss of tensile strength followed by a loss of mass. Absorption test in rats and in vitro hydrolysis show that PEGESORB rapid suture retains a minimum of 50% knot strength at 5 days. All of the original tensile strength of PEGESORB rapid is essentially lost by 10-14 days post implantation. Mass absorption of Pegesorb rapid takes place after approximately 42 days.
PEGESORB rapid sutures are available as sterile, braided, undyed (natural) strands in sizes USP 5/0 - USP 2 (metric sizes 1 - 5), in a variety of lengths, with or without various needles.
Sutures are presented in one and two dozen boxes.
The product should be kept dry and clean. Store below 30ºC and keep away from direct sunlight and moisture. Do not use products after expiry (“use by”) date.
PEGESORB rapid sutures, being absorbable, should not be used where extended approximation of tissue is required. PEGESORB rapid should not be used where approximation of tissues beyond 7 days or wound support beyond 7 days is required.
Users should be familiar with surgical procedures and techniques before employing absorbable sutures for wound closure, as risk of wound dehiscence may vary with the site of application and the suture material is used. Users should consider the in vivo performance, under ACTIONS section, when selecting a suture. The use of this suture may be inappropriate in elderly malnourished or debilitated patients, or in patients suffering from conditions which may delay wound healing.
As with any foreign body, prolonged contact of any suture with salt solutions, such as those found in the urinary or biliary tracts may result in calculus formation. As this is an absorbable suture material; it may act transiently as a foreign body. Acceptable surgical practice should be followed for the management of contaminated or infected wounds.
The use of supplemental non-absorbable sutures should be considered by the surgeon in the closure of the sites which may undergo expansion, stretching, or distention, or which may require additional support.
As any foreign material in the presence of bacterial contamination may enhance bacterial infectivity, acceptable surgical practice must be followed with respect to drainage, and closure of contaminated or infected wounds.
Sterility is preserved only when opened under sterile conditions.
Do not re-sterilize.
Store at room temperature and avoid prolonged exposure to elevated temperatures.
Discard opened packages and unused sutures. Do not use opened or damaged products.
This device is single use. Known hazards with reuse or re-sterilization of opened/original packages of the device are cross contamination, infection, early degradation, trauma.
In handling this or any other suture material, care should be taken to avoid damage from handling. Avoid crushing or crimping damage due to application of surgical instruments such as forceps or needle holders.
As with any suture material, adequate knot security requires the accepted surgical technique of flat and square ties with additional throws as warranted by surgical circumstance and the experience of the surgeon.
Skin sutures which must remain in place longer than 7 days may cause localized irritation and should be snipped off or removed as indicated.
Under some circumstances, notably orthopedic procedures, immobilization of joint by external support may be employed at the discretion of the surgeon.
Consideration should be taken in absorbable sutures in tissues with poor blood supply as suture extrusion and delayed absorption may occur.
To avoid damaging needle points and swage areas, grasp the needle in an area one-third (1/3) to one-half (1/2) of the distance from the swaged end to the point. Reshaping needles may cause them to lose strength and be less resistant to bending and breaking.
Users should exercise caution when handling surgical needles to avoid inadvertent needle sticks.
Discard used needles in "sharps" containers.
Do not use expired products.
Adverse effects associated with the use of this device include wound dehiscence, failure to provide adequate wound support in closure of the sites where expansion, stretching or distention occur, failure to provide adequate wound support in elderly malnourished, or debilitated patients, or in patients suffering form conditions which may delay wound healing, calculi formation in urinary and biliary tracts when prolonged contact with salt solutions such as urine and bile occurs, infection, minimal acute inflammatory tissue reaction, and transitory localized irritation when skin sutures are left in place for greater than 7 days, suture extrusion and delayed absorption in tissue with poor blood supply.
Broken needles may cause complications in extended or additional surgeries or residual foreign bodies. Inadvertent needle sticks with contaminated surgical needles may result in the transmission of blood borne pathogens.